What to Look for When Buying a Polytunnel

Charles Dowding
Monday, 4th January 2016

Charles Dowding explains all you need to know when looking into buying a polytunnel: size, placing, ventilation, material and maintenance.

Polytunnels are wonderful structures and good value compared to greenhouses. Once erected they will be there for several years, so check out my tips before buying.

I have used polytunnels since 1983 when I bought three, each being 18×55 feet (5.5x17m). They served me well except that their 1in tubes were a little too thin for my exposed site; in a gale of March 1988, one of them collapsed after the wind ripped out its polythene on the far side.

How big?

I would buy the largest you can fit into your area, because the space is useful for storage and drying washing as well as for growing and one always finds more to plant in a tunnel. Hoops are usually 5 feet (1.5m) apart so length is multiples of that. I reckon that 20-30 feet is a good length for even ventilation, whereas tunnels of say 60 feet length can have pockets of ‘dead’ unventilated air in the middle.

Orientation

• North to south is ideal so that tall crops in summer cause equal amounts of shade to either side, also to reduce overheating in summer.

• An east-west structure is face on to the midday sun and in a hot climate this is not ideal during summer. It also means some shading of crops in the north bed when summer crops grow tall in the middle.

However any orientation is possible and I have tried many, with success. Other important factors to consider are aligning a tunnel up-and-down any slope (beds across slope are harder to water and mulch), and having the doors at convenient points for access and watering.

Ventilation

Plants like fresh air and its important they have enough, rather than striving for maximum heat. Air in a polytunnel circulates from one end to the other, and if possible I recommend leaving a gap between the top of doors and the frame above them, say 6in (15cm), so that a small amount of air can always flow through and increase carbon dioxide levels, without a draught at ground level. I find that winter salads stay healthy, without mildew problems, yet without any need to open and close doors for much of the winter. One job saved!

The option of side vents (instead of the polythene going to ground level) is in my opinion not necessary or suitable for vegetables, because it reduces temperature too much in windy weather, and the doors offer enough possibility to admit fresh air. It's cheaper, simpler and more effective to cover the hoops with polythene only, to ground level and below. Keep side vents for long tunnels only, above a length of 40-50 feet (13-16m).

Polythene attached at ground level, or buried?

I recommend burying the polythene all around in trenches of one spade’s depth, in order to have a polythene barrier in the ground. This protects against:
• pests entering, such as rabbits, slugs, cats and dogs
• weeds creeping in, including couch grass, buttercup, bindweed
• too much draught and cold air around plants’ leaves.

It is sometimes claimed to be easier and quicker to attach polythene at ground level to battens or rails. But having tried this, I do not agree, because before doing that, you need to dig holes for the foundation tubes rather than simply knocking them in, also you may need some concrete in there for windy sites. All the fixings you need involve extra expense and are only worthwhile if there is simply no room to dig a trench.

Foundation tubes

When burying polythene in a trench, tubes simply need to be hammered into the ground about 12-18in (30-45cm), where their role is to give the structure some rigidity, that is all. When polythene is bured, the tubes are not anchoring the structure in place, but keeping it steady in wind.

In contrast to this, when polythene is attached to a rail and not buried, the foundation tubes have more importance as they are what holds the structure in the ground (rather than the buried polythene) and so you need more expensive tubes with metal brackets on their ends, and each one requires a dug hole, sometimes with concrete.

While we were looking at this on one of my courses, a participant lamented how her new tunnel had blown away within a month - the polythene was attached to rails, rather than buried. Exceptions to the above are sheltered gardens, and sites where you cannot dig a trench e.g. too much gravel, concrete etc. But then it is difficult to dig holes for foundation tubes too.

Crop support bars

Although an 'extra', I would always buy these, so you have support for climbing plants from tomatoes and cucumbers to beans and melons. They span across from side to side at about or just over 6ft (2m) high, so you can walk underneath, yet also reach to tie strings or stakes.

Re-cladding

Polythene needs replacing every 5-8 years, depending how windy your site is and how tight you can stretch it. Polythene is easier to make tight when the cover is put on in warm sunshine, if possible. I have often done it in January and managed alright, but the skin is definitely slacker and more prone to damage than when clad in warm sunshine.

What kind of polythene?

More types become available and choosing is then difficult. From tunnels I have seen with the more expensive thermic or anti-condensation polythene, I doubt that their extra cost is worthwhile. I recommend the standard, light-diffusing polythene which admits around 89% of daylight. Always use horticultural grade polythene, which has a UV stabiliser, without which it would be brittle and break within a year.

A friend recently noticed the great clarity of my standard, light diffusing polythene which is now three years old. I had recently washed it with a wet sheet and brush to remove lichen and moss.

Doors

You use these a lot so suffice to say, they are worth spending money on to have the ones you like. Home-made is certainly possible, note my tips on ventilation. It's the area where you can be most creative, especially if you enjoy carpentry. For door frames, 4×2.

This article is cross-poted from: hwww.charlesdowding.co.uk/polytunnels-advice-on-buying/

Charles Dowding runs courses on market gardening and no-dig. Find out more here: www.charlesdowding.co.uk/courses/homeacres-courses

No Dig Organic Home and Garden by Charles Dowding and Stephanie Hafferty

Further resources

How to Grow Food in Your Polytunnel All Year Round for just £9.95

The Winter Polytunnel

How to make a bamboo polytunnel

How to buy, site and erect a polytunnel

PCM86.jpgNEW ENHANCED 
PERMACULTURE SUBSCRIPTION

Exclusive content and FREE digital access to over 20 years of back issues

SUBSCRIBE:
www.permaculture.co.uk/Subscribe

Trial your FREE digital copy HERE!

Steve Smith |
Thu, 07/01/2016 - 21:35

Where I live, I need the side vents. last summer the temperature hit 40 degrees some days, so the tunnel was always open. And full of insects and bees. If I only have the doors open, the plants cook! I'm very lucky here as it is never windy - a slight breeze is cause for alarm. But we do get sudden and very violent thunderstorms, sometimes with hail even in August so the tunnel canopy is essential. And of course, in the winter I can get good results with the sides closed, even in the snow.

add comment

Log in or register to post comments